Tim's BB4

Tim · Post by **Tim** » Sat Dec 30, 2023 5:53 pm

Transferring myself over from the new members post.

Very happy to be ending the year with a MOT pass

Failed first time around on emissions. Talking to the garage they were giving it a full cat emissions test, but my understanding is that as a pre-95 import the BB4 model is not in the emissions standard book so should be given an easier emissions test. If anyone knows for sure I'd be interested to know.

89 UKDM BA4 4WS (resto job!) · Post by **wurlycorner** » Sat Dec 30, 2023 6:42 pm

Hi Tim
Good news on the pass.
That's correct - a BB4 should be tested to non-Cat emissions standard.

Post by **Drax** » Tue Jan 02, 2024 9:30 am

great to hear Tim! keep any updates to the car coming, big or small

toadster · Post by **toadster** » Wed Jan 03, 2024 10:51 am

Lo

Great stuff

Cheers

Toadster

Tim · Post by **Tim** » Wed Apr 03, 2024 5:17 pm

First breakdown of the year, the starter motor stuck with no advance warning. At least it was at home at the time. Looked accessible but the bottom bolt needed a big extension. When taking the expansion bottle off found the rubber tube was split and the plastic pipe was blocked, lucky to spot those at the same time. Then the battery retaining clamp was threaded, took one off a sleeping Hillman Avenger which fits nicely.

Come to use the car yesterday and the engine light came on almost immediately

pass me a paperclip

Post by **JEBB4** » Thu Apr 04, 2024 11:35 am

Nice work
What fault code did you get?

Tim · Post by **Tim** » Fri Apr 05, 2024 2:01 pm

Code 41 was the new one. Thinking back, I topped up the clutch fluid right before it came on, I had a look to see if I disturbed any wiring but can't see anything obvious. Also have code 17 regularly as the speedometer connection drops.

Post by **Drax** » Fri Apr 05, 2024 3:59 pm

error codes
kb/viewarticle?a=4

17 - VSS: Vehicle Speed Sensor - P0500 (circuit malfunction), P0501 (range/performance)
41 - Primary Oxygen Sensor Heater (HO2S) - P0135 (circuit malfunction), P1166 (system electrical), P1167 (system)

Scott560 · Post by **Scott560** » Sun Apr 14, 2024 4:40 pm

I have found that previously if the starter motor gets stuck on / doesn't disengage, it can play funny buggers with the voltage and make the car throw a few codes. If disconnecting the battery for an hour and a bit of driving doesn't clear any of the codes then it could well be true (whether caused by the starter issue or not - if you haven't driven the car much faults might just start to crop up coincidentally).